開混凝土罐車需要注意什么？

 來源：http://www.ranhaofz.cn 日期：2023-01-23 發布人：admin
攪拌車所運輸?shù)幕炷烈ＷC其質量及塌落度符合混凝土行業的標準及要求。
The quality and slump of the concrete transported by the mixer truck shall meet the standards and requirements of the concrete industry.
小型攪拌車在道路上行駛，其上裝的加長料槽要放置在卸料溜槽的支架上并用掛鉤固定好，不允許掛在主排料槽上工作，主卸料槽要旋轉到固定的位置，拉下定位手柄，用鎖緊手柄將彈簧變幅組織鎖緊，避免由于不固定而晃動，造成傷人及其它事故。
When the small mixer is driving on the road, the extended chute installed on it should be placed on the bracket of the discharge chute and fixed with a hook. It is not allowed to work on the main discharge chute. The main discharge chute should rotate to a fixed position, pull down the positioning handle, and use the locking handle to lock the spring luffing fabric to avoid personal injury and other accidents caused by shaking due to unfixed.
攪拌車上裝設備連續工作時間不能超過8個小時。
The continuous working time of the equipment on the mixer truck shall not exceed 8 hours.
大型攪拌車在混凝土運輸過程中上裝罐體不能停轉，否則會造成混凝土凝結，而且停轉后重新啟動時會對液壓系統和減速機造成沖擊，導致液壓泵和馬達的損壞。
The loading tank of the large mixer truck cannot be stopped during concrete transportation, otherwise it will cause concrete condensation, and the restart after stopping will impact the hydraulic system and reducer, causing damage to the hydraulic pump and motor.
自上料混凝土攪拌罐車
攪拌車在卸料的時候，如果發現混凝土水分蒸發過多，塌落度偏低，不能滿足質量要求，可以適當?shù)耐迌?nèi)加水，然后以10-14轉/分的速度旋轉30分鐘后再卸料，讓混凝土充分?jǐn)嚢琛?/div>
When the mixer truck is discharging, if it is found that the concrete moisture evaporates too much and the slump is too low to meet the quality requirements, it can properly add water to the tank, and then rotate at the speed of 10-14 rpm for 30 minutes before discharging, so that the concrete can be fully mixed.
攪拌車在空載中上裝罐體也不可以停轉，否則在行車過程中車輛的晃動很容易造成滾道和托輪部分磕碰的，這樣托輪和滾道就會過早的損壞。
The mixing truck can not be stopped when loading the tank in the empty state. Otherwise, the shaking of the vehicle during the driving process can easily cause partial collision between the roller path and the roller path, so the roller path and the roller path will be damaged prematurely.
攪拌車駕駛員要記住，在工作過程中壓力水箱的水要常常加滿，備用，在水箱加水前要打開氣閥將內部的空氣放掉，在沖洗車輛后或者停用時要將水箱內的空氣放掉。在冬天，工作結束后要將水箱內的水放掉，不得有剩水，否則容易結冰凍壞水箱。
The driver of the mixing truck should remember that the water in the pressure tank should always be filled up during the working process, for standby, and the air valve should be opened before the water tank is filled to drain the air inside, and the air in the tank should be drained after the vehicle is washed or when it is out of service. In winter, the water in the water tank shall be drained after the work is finished, and there shall be no water left, otherwise the water tank will be easy to freeze.
混凝土攪拌車在滿載混凝土?xí)r罐體正轉，如果需要反轉，就須等罐體停穩后再將手柄扳到反轉位置。一個合格的攪拌車司機能夠做到以上這幾點
When the concrete mixer truck is full of concrete, the tank body turns forward. If it needs to reverse, the handle must be pulled to the reverse position after the tank body stops stably. A qualified mixer driver can do the above
本文由自上料混凝土攪拌罐車友情奉獻.更多有關的知識請點http://www.ranhaofz.cn真誠的態度.為您提供為全面的服務.更多有關的知識我們將會陸續向大家奉獻.敬請期待
This article is dedicated by the self-feeding concrete mixer truck. For more information, please click http://www.ranhaofz.cn Sincere attitude. We will provide you with comprehensive services. We will continue to offer you more relevant knowledge. Please look forward to it
上一篇：自上料攪拌車自重的調節的方法
下一篇：防止自上料攪拌車混凝土沾罐的方式有哪些？