變速箱是一個重要的部分混合汽車變速箱操作得當,可以使汽車石油儲蓄,正確操作變速箱,可以延長使用壽命,所以每個人的駕駛攪拌機,必須充分理解傳播,在使用的過程中自上料混凝土攪拌罐車變速箱或一些注意事項。

　　Gearbox is an important part of the proper operation of the gearbox of the hybrid vehicle, which can save the oil of the vehicle, operate the gearbox correctly, and prolong the service life. Therefore, everyone's driving mixer must fully understand the transmission, and in the process of use, the variable speed box of the concrete mixer or some precautions.

　　1. 當混合車換擋時，離合器必須完全分離，變速桿必須到位。

　　1. When the mixer is shifting, the clutch must be completely disengaged and the gear lever must be in place.

　　2. 攪拌器的齒輪箱有高檔次和低檔次之分。停車時，變速箱變速桿應置于低檔空檔位置。

　　2. The gearbox of agitator can be divided into high-grade and low-grade. When parking, the transmission gear lever should be placed in the low neutral position.

　　3.當攪拌器處于低擋或倒檔時，應先停車，然后將其置于檔位，以避免損壞傳動裝置內的部件。當攪拌器處于換擋狀態時，必須使用較大的檔位來克服換擋鎖的阻力。

　　3. When the agitator is in low gear or reverse gear, stop it first, and then put it in gear to avoid damaging the parts in the transmission device. When the agitator is in the shift state, a larger gear must be used to overcome the resistance of the shift lock.

　　4. 當變速器從低檔到高檔換擋時，不要跳檔操作，否則會影響分機同步器的使用壽命。

　　4. When the transmission shifts from low gear to high gear, do not shift, otherwise it will affect the service life of the extension synchronizer.

　　5. 當混合器下坡時，不要改變高低檔區。

　　5. When the mixer goes downhill, do not change the high and low range.

　　6. 根據路面情況，攪拌器應從1個或2個街區開始。

　　6. According to the road conditions, the mixer shall start from 1 or 2 blocks.

　　7. 在混合器啟動前，應先松開制動器。帶止動閘的混合器連接到剎車閥后，必須等待氣壓上升到要求的壓力后才能進入檔位。

　　7. Release the brake before starting the mixer. After the mixer with stop brake is connected to the brake valve, it must wait for the air pressure to rise to the required pressure before entering the gear.

　　8. 如果在混合器使用過程中發現變速器有異常聲音，且運轉明顯沉重等異常現象，應立即停機檢查，故障排除后繼續驅動。

　　8. If the abnormal sound of the transmission is found during the use of the mixer, and the operation is obviously heavy, stop the machine immediately for inspection, and continue to drive after troubleshooting.

　　9. 如果攪拌器在換擋過程中不能進入檔位，則需要檢查量程缸及其氣路，以確保分機進入檔位。

　　9. If the agitator cannot enter the gear during the shift, it is necessary to check the range cylinder and its air circuit to ensure that the extension enters the gear.

　　10. 在“三包”期間，一般不允許擅自拆裝混合器的變速箱。

　　10. During the period of "Three Guarantees", it is generally not allowed to dismantle the gearbox of the mixer without permission.

　　以上內容由攪拌車整理發布，更多相關信息可以點擊官網進行咨詢：http://www.ranhaofz.cn/

　　The above content is collated and released by Zhongke Jufeng mixer. For more information, please click the official website for consultation: http://www.jufengjiabangji.com/