Method 1:

1、準備好緊急驅動軟管，將故障商品混凝土水泥攪拌運輸車熄火，卸下液壓馬達上的高壓油管接頭。

1. Prepare the emergency drive hose, turn off the faulty commercial concrete cement mixer truck, and remove the high-pressure oil pipe connector on the hydraulic motor.

2、將救援車熄火，將其液壓馬達的高壓油管卸下，并與故障車上的對應接頭用緊急驅動軟管相連。

2. Turn off the rescue vehicle, remove the high-pressure oil pipe of its hydraulic motor, and connect it with the corresponding connector on the faulty vehicle with emergency drive hose.

3、發動救援車，將其操縱手柄撥至出料位置，故障車內的商品混凝土即被排出。

3. Start the rescue vehicle, turn its control handle to the discharge position, and the commercial concrete in the faulty vehicle will be discharged.

4、緊急驅動完畢后，將驅動軟管卸下，并恢復兩車原狀。

4. After the emergency drive, remove the drive hose and restore the two vehicles to their original state.

方法二：

Method 2:

1、若一個方法實行有困難，則必須采用以下方法，立即排出商品混凝土。

1. If it is difficult to implement one method, the following methods must be used to discharge the commercial concrete immediately.

2、在托輪和滾道之間放入木楔，以控制攪拌筒的旋轉，一定要注意安全;將發動機熄火，拆松液壓馬達的一根高壓油管，攪拌筒可自由旋轉，控制攪拌筒的旋轉，使維修孔轉到下部，然后打開維修孔，清理出筒內商品混凝土。此時一定要注意安全，商品混凝土排出完畢后，恢復商品混凝土水泥攪拌運輸車原狀。

2. Put a wooden wedge between the supporting wheel and the raceway to control the rotation of the mixing drum. Be sure to pay attention to safety; Turn off the engine, remove a high-pressure oil pipe of the hydraulic motor, the mixing drum can rotate freely, control the rotation of the mixing drum, turn the maintenance hole to the lower part, and then open the maintenance hole to clean out the commercial concrete in the drum. At this time, attention must be paid to safety. After the commercial concrete is discharged, the commercial concrete cement mixer truck shall be restored to its original state.

方法三：用“風炮”打碎凝結的混凝土，然后一點點鏟出來。

Method 3: break the set concrete with an "air cannon" and shovel it out a little bit.

罐體下部要割開一個口，加翻開一個原來就有用羅絲上緊的一個封蓋，這個蓋是讓有需求進去工作時翻開通風和緊急情況用來放料的。而在打罐過程中人在罐里面要通風，在裝料罐入口放臺風扇吹風進去，而“風炮”工作時會搞起灰塵，又要接上水管淋濕打碎的混凝土。把罐里面的再混凝土打碎鏟出以后再打割開部分焊接上，上回封蓋，裝滿水試下轉動能否正常，再少量裝料遞增看液壓機工作能否正常，一切正常即可以繼續運作了。

A opening shall be cut at the lower part of the tank body, and a cover tightened with rose shall be opened. This cover is used to turn on the air and discharge materials in case of emergency. In the process of tank beating, people should ventilate in the tank and put a fan at the inlet of the charging tank to blow in. When the "air cannon" works, it will cause dust and connect a water pipe to wet the broken concrete. After the concrete in the tank is broken and shoveled out, the cut part shall be welded, the upper cover shall be sealed, the water shall be filled to test whether the rotation is normal, and then a small amount of loading shall be increased to see whether the hydraulic press works normally. If everything is normal, it can continue to operate.

緊急清理水泥攪拌運輸車內商品混凝土是每個水泥攪拌運輸車司機都應該會的，在水泥攪拌運輸車發生故障的時候，及時清理，可以將損失降到低。

Every driver of cement mixer truck should be able to clean the commercial concrete in the cement mixer truck urgently. When the cement mixer truck breaks down, clean it in time to reduce the loss.